Product ID:LORD 506 (VERSILOK 506) ADHESIVE
MSDS Date:10/24/1997
FSC:8040
NIIN:01-170-3599
Status Code:A
MSDS Number: CKFZN

LORD CORPORATION

2000 WEST GRANDVIEW BLVD
ERIE, PA 16514-0038
US

Emergency Phone: 1-814-763-2345

Info Phone: 814-868-3611

Cage: 30676

LORD CORPORATION, CHEMICAL PRODUCTS DIVISION

ERIE, PA 16514-0038 US

Telephone: 814-868-3611

Cage: 30676

METHYL METHACRYLATE

CAS: 80-62-6

RTECS: OZ5075000

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYLACRYLIC ACID

CAS: 79-41-4

RTECS: OZ2975000

ACGIH TLV: 70 MG/M3;20 PPM

AMINE CURATIVE

RTECS: AC1008113

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:PINK PASTE, WITH SWEET ODOR.
FLAMMABLE LIQUID. MAY CAUSE ALLERGIC SKIN REACTION. CAUSES SKIN
AND EYE IRRITATION. CAUSES RESPIRATORY TRACT IRRITATION. CHRONIK
SKIN CONTACT MAY CAUSE DERMATITIS. C AUSES SKIN IRRITATION.
Effects of Overexposure:EYE CONTACT: CAUSES EYE IRRITATION. SKIN
CONTACT: MAY CAUSE SKIN SENSITIZATION. MAY CAUSE DERMATITIS.
CAUSES SKIN IRRITATION. INHALATION: MAY CAUSE HEADACHE AND
NAUSEA. CAUSES RESPIRATORY T RACT IRRITATION. INGESTION:
HARMFUL IF SWALLOWED. INGESTION IS NOT AN EXPECTED ROUTE OF ENTRY
IN INDUSTRIAL OR COMMERCIAL USES.

First Aid:EYE:FLUSH IMMEDIATELY WITH LARGE AMOUNT OF WATER FOR AT LEAST
15 MINUTES HOLDING EYELIDS OPEN WHILE FLUSHING.GET PROMPT MEDICAL
ATTENTION.SKIN:FLUSH CONTAMINATED SKIN WITH LARGE AMOUNTS OF WATER
WHILE REMOVING CONTAMINATED CLOTHING.WASH AFFECTED SKIN AREAS WITH
SOAP AND WATER.GET MEDICAL ATTENTION IF SYMPTOMS
OCCUR.INHALATION:MOVE PERSON TO FRESH AIR.RESTORE AND SUPPORT
CONTINUED BREATHING.IF BREA THING IS DIFFICULT,GIVE OXYGEN.GET
IMMEDIATE MEDICAL ATTENTION.INGESTION:INDUCE VOMITING IMMEDIATELY
AS DIRECTED BY MEDICAL PERSONNEL.NEVER FIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.GET MEDICAL ATTENTION IMMEDIATELY.

Flash Point Method:CC
Flash Point:=11.7C, 53.F
53F
Lower Limits:1.6
Upper Limits:8.8
Extinguishing Media:CO2, DRY CHEMICAL, FOAM,
Fire Fighting Procedures:WEAR FULL FIREFIGHTING PROTECTIVE CLOTHING,
INCLUDING SELF-CONTAINED BREATHING APPARATUS (SCBA). WATER SPRAY
MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
DURING A FIRE, IRRITAT ING AND OR TOXIC GASES AND PARTICULATES MAY
BE GENERATED BY THERMAL DECOMPOSITION OR COMBUSTION.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID AND VAPOR. KEEP
CONTAINERS TIGHTLY CLOSED. ISOLATE FROM HEAT, ELECTICAL EQUIPMENT,
SPARKS, OPEN FLAME, AND OTHER SOURCES OF IGNITION. CLOSED
CONTAINERS MAY RUPTURE WHEN EXPOSED TO EXTREME HEAT. USE WATER
SPRAY TO KEEP FIRE EXPOSED CONTAINERS COOL. FLAMMABLE LIQUID
CLASS IB

Spill Release Procedures:KEEP NON-ESSENTIAL PERSONNEL SAFE DISTANCE
AWAY FROM SPILL AREA.REMOVE ALL SOURCES OF IGNITION (FLAME,HOT
SURFACES,AND ELECTRICAL,STATIC OR FRICTIONAL SPARKS).AVOID
BREATHING VAPORS.USE SCBA.NOTIFY AP PROPRIATE AUTHORITIES IF
NECESSARY.AVOID CONTACT.USE NON-SPARKING TOOLS,SCOOP SPILLED
MATERIAL INTO CONTAINER FOR PROPER DISPOSAL.(IF NECESSARY,USE INERT
ABORBENT MATERIAL TO AID IN CONTAINING SPILL).

Handling and Storage Precautions:REFER TO OSHA 29 CFR PART 1910.106
"FLAMMABLE AND COMBUSTIBLE LIQUIDS" FOR SPECIFIC STORAGE
REQUIRMENTS. STORE ONLY IN WELL-VENTILATED AREAS. KEEP CONTAINER
CLOSED WHEN NOT IN USE.
Other Precautions:KEEP CLOSURE TIGHT AND CONTAINER UPRIGHT TO PREVENT
LEAKAGE. GROUND AND BOND CONTAINERS WHEN TRANSFERRING MATERIAL.
AVOID SKIN AND EYE CONTACT. WASH THOROUGHLY AFTER HANDLING. AVOID
BREATHING OF V APOR OR SPRAY MISTS.*

Respiratory Protection:USE A NIOSH/MSHA APPROVED AIR-PURIFYING ORGANIC
VAPOR RESPIRATOR IF OCCUPATIONAL LIMITS ARE EXCEEDED. FOR
EMERGENCY SITUATIONS, CONFINED SPACE USE, OR OTHE CONDITIONS WHERE
EXPOSURE LIMITS MAY BE GRE ATLY EXCEEDED, USE AN APPROVED
AIR-SUPPLIED RESPIRATOR. OBSERVE OSHA REGULATIONS (29 CFR
1910.134) FOR RESPIRATOR USE.
Ventilation:SUFFICIENT VENTILATION IN PATTERN AND VOLUME SHOULD BE
PROVIDED IN ORDER TO MAINTAIN AIR CONTAMINANT LEVELS BELOW
RECOMMENDED EXPOSURE LIMITS.
Protective Gloves:USE NEOPRENE, NITRILE, OR RUBBER GLOVES TO PREVENT
SKIN CONTACT.
Eye Protection:SAFETY GLASSES WITH SIDE SHIELDS AND CHMICAL GOGGLES
Other Protective Equipment:USE DISPOSABLE OR IMPERVIOUS CLOTHING IF
WORK CLOTHING CONTAMINATION IS LIKELY. REMOVE AND WASH
CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
TOILET FACILITY. FOOD OR BEVERAGES SHOULD NOT BE CONSUMED ANYWHERE
THIS PRODUCT IS HANDLED OR STORED. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SUFFICIENT VENTILATION (USING EXPLOSION-PROOF EQUIPMENT) SHOULD BE
PROVIDED TO PREVENT FLAMMABLE VAPOR/AIR MIXTURES FROM ACCUMULATING.

Boiling Pt:>101.1C, 214.F
B.P. Text:214-322F
Vapor Density:>AIR
Spec Gravity:1.0
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:PINK PASTE/SWEET ODOR

Stability Indicator/Materials to Avoid:YES
INORGANIC ACIDS, ORGANIC ACIDS, CAUSTICS, AMINES, PEROXIDES,
POLYMERIZATION INHIBITORS.
Stability Condition to Avoid:STORAGE ABOVE 100' F. EXPOSURE TO
SUNLIGHT, ULTRAVIOLET LIGHT IRRIDATION. AVOID DROPPING OR PUNCTURE
OF CONTAINERS.
Hazardous Decomposition Products:CO2, CO, OXIDEES OF NITROGEN

Waste Disposal Methods:DISPOSAL SHOULD BE DONE IN ACCORDANCE WITH
FEDERAL (40 CFR PART 261), SATET AND LOCAL ENVIRONMENTAL CONTROL
REGULATIONS. IF WASTE IS DETERMINED TO BE HAZARDOUS, USE LICENSED
HAZARDOUS WASTE TRANSPORT ER AND DISPOSAL FACILITY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:DO NOT HANDLE UNTIL ALL SAFETY PRECAUTIONS HAVE BEEN READ
AND UNDERSTOOD. USE WITH ADEQUATE VENTILATION. BECAUSE EMPTY
CONTAINERS MAY RETAIN PRODUCT RESIDUE AND FLAMMABLE VAPORS, KEEP
AWAY FROM HEAT , SPARKS AND FLAME; DO NOT CUT, PUNCTURE OR WELD ON
OR NEAR THE EMPTY CONTAINER. DO NOT SMOKE WHERE THIS PRODUCT IS
USED OR STORED.

Transport Information:DOT NAME: ADHESIVE UN # 1133 EMERGENCY
RESPONSE GUIDE NUMBER 26 PACKING GROUP: II

State Regulatory Information: